del Sol Power Steering Question

My girlfriend's '94 del Sol needs new seals on its
power steering unit. It doesn't look like that big
of a sweat to do it myself. (The local garages
and dealers all want ~$500.)

Question: Does taking the pump apart and replacing
the gaskets and seals involve special tools? Or is
this a fairly straightforward thing to do, including
refilling the system with fluid?

I'll check for responses at these two newsgroups,
or you can write to me at the address below.

Much thanks for any guidance on this.

Bob (armistead_rap(AT)bigfoot.com)

 

I was considering this a few years ago for the PS pump on my
91 Civic, when I thought it was leaking. Turned out it was
fine, but I learned a few things, anyway.

I was prepared to do the job myself and got as far as
ordering a gasket kit from Autozone, which now I do not
recommend. I think it's a DIY job, but I can't say for
sure. If you do try to do it yourself, I would buy an OEM PS
pump gasket kit from a place like www.slhonda.com .
Aftermarket seals seem to have a much shorter life than
genuine Honda (= OEM) ones.

The other interesting thing I observed was that I could have
a PS pump from a junkyard for under $100. If the mileage on
the junk car is under say 100k miles, then I think it's a
pretty safe bet that the pump will have seen only Honda
fluid inside it.

From reports here and my own experience with my 91 Civic, if
one uses the correct PS fluid (Honda only), the seals should
last a very long time.

What happened? Did she put non-Honda power steering fluid
into the system?

 

I was considering this a few years ago for the PS pump on my
91 Civic, when I thought it was leaking. Turned out it was
fine, but I learned a few things, anyway.

I was prepared to do the job myself and got as far as
ordering a gasket kit from Autozone, which now I do not
recommend. I think it's a DIY job, but I can't say for
sure. If you do try to do it yourself, I would buy an OEM PS
pump gasket kit from a place like www.slhonda.com .
Aftermarket seals seem to have a much shorter life than
genuine Honda (= OEM) ones.

The other interesting thing I observed was that I could have
a PS pump from a junkyard for under $100. If the mileage on
the junk car is under say 100k miles, then I think it's a
pretty safe bet that the pump will have seen only Honda
fluid inside it.

From reports here and my own experience with my 91 Civic, if
one uses the correct PS fluid (Honda only), the seals should
last a very long time.

What happened? Did she put non-Honda power steering fluid
into the system?

 

there's a reason for that...

no, it's a huge pita. much better to use reconditioned units. avoid
avoid avoid anything but honda-specific power steering fluid - non-honda
fluid ruins the seals.

 

there's a reason for that...

no, it's a huge pita. much better to use reconditioned units. avoid
avoid avoid anything but honda-specific power steering fluid - non-honda
fluid ruins the seals.

 

The front seal by the pulley can be replaced without too much difficulty.
Use both genuine Honda parts and power steering fluid. Non-Honda fluid
causes the seals in the steering rack to leak.

Eric

 

The front seal by the pulley can be replaced without too much difficulty.
Use both genuine Honda parts and power steering fluid. Non-Honda fluid
causes the seals in the steering rack to leak.

Eric

 

OK, the above statement was for older power steering pumps. It seems that
Honda had redesigned it and made it more difficult to replace the front
seal. Compare the older pump from an Accord http://tinyurl.com/mvl8r with
the '94 Del Sol http://tinyurl.com/nmbky. Oh well...

Eric

 

OK, the above statement was for older power steering pumps. It seems that
Honda had redesigned it and made it more difficult to replace the front
seal. Compare the older pump from an Accord http://tinyurl.com/mvl8r with
the '94 Del Sol http://tinyurl.com/nmbky. Oh well...

Eric

 

Thanks for the comprehensive response. Good suggestion,
getting a used pump.

No non-Honda fluid was used by her, but who knows what
others who've tended her car might have used . . .

thanks,

Bob

 

Thanks for the comprehensive response. Good suggestion,
getting a used pump.

No non-Honda fluid was used by her, but who knows what
others who've tended her car might have used . . .

thanks,

Bob

 

Roger that, Jim. Thanks.

Bob

 

Roger that, Jim. Thanks.

Bob

 

I will check out those sites. Much thanks.

Bob

 

I will check out those sites. Much thanks.

Bob